For bedding seams, mouldings, rails, window and door frames and many other types of covered joints in portable buildings, caravans, holiday homes, boats, freight containers and transport vehicles.
Soudal Butyrub is a Polybutene Based Non Setting Mastic which forms an elastic tight skin that can be painted over after 24 hours.
Surface preparation: All surfaces must be clean, dry and free from frost, grease and loose materials. Apply primer if required. In situations where an especially neat finish is required, use masking tape to cover the face edges of the joint and remove immediately once tooling has been completed Cut the top of the screw thread off the cartridge and screw on the nozzle. Cut nozzle to correct diameter for joint size. Apply using a skeleton or powered gun into the joint ensuring good contact with surfaces.
Properties Application temperature range: +5ºC to +30ºC Curing: Seamseal CV cures by evaporation of solvent. Full cure normally occurs in 2-4 days. Rate of cure will depend on thickness, ambient temperature, joint size and design. Lower temperatures and drier conditions will result in a slower rate of cure. Priming: Primers are not normally required for good adhesion to most metals. Shelf life: 12 months when stored in cool, dry conditions. Skinning time: Does not skin. The surface of the sealant will appear dry to the touch after several days but will remain pliable beneath the surface. Working time: Approximately 20 minutes.
PLEASE NOTE THE DATE ON THE SEALANT IS DATE OF MANUFACTURE NOT EXPIRY DATE THIS PRODUCT IS GOOD FOR 1 YEAR FROM THIS DATE.
High performance bedding sealant with a solvented release curing system.
Good adhesion to a wide variety of surfaces, especially coated metals.
Excellent application characteristics either with hand applied or air operated
Easy to tool and clean off using Hodgson’s Caravan Sealant Cleaner.
Does not form a skin but leaves a dry surface which remains pliable after
This is super sticky and will seal any joint with ease
by Will (04 Mar 2017)
great service from store, will be using when we have dry weather
by Christine Keller, Australia (07 Dec 2016)
Fantastic Service! Thanks
Does What It Says
by M Brooks (08 Jun 2016)
What is there to say about a sealant? It does what it says.
by Martin F (28 Apr 2016)
This Hodgson Mastic Non-Setting Caravan Sealant was easy to apply and went on where I wanted it to thanks to the nozzle - some nozzles are too big, but not this one.
I was very pleased with the price and it was an excellent purchase.
My only concern will be its longevity, but that is something I can only wait and see on that.
by Mr Keating (07 Jul 2015)
worked perfectly, you do get sticky using it so lots of white spirit and gloves
Non Setting Mastic
by Mike (01 Apr 2015)
Just as good as sikaflex but less than half the price
by Mr Hill (08 Oct 2014)
Bought this to seal shower and sink. Expected smaller tube in 2 aspects, I misread ad' had to borrow industrial sized gun, but will come in handy again. Just the job.
Non Setting Sealant
by Allen H (31 Jul 2014)
Ideal product for sealing around components that penetrate the shell of the caravan. I used it on a replacement water housing and around the fridge vents. The component can be removed and repositioned.
The cartridge is about 20mm longer than the standard DIY cartidge. I had to chop 20mm off the tube to be able to fit it into my DIY dispenser.
by Mr lawson (19 Aug 2013)
this is an excellent product and gives a very good seal on all joints
bought the Carafax sealant to reseal joints on motorhome panels,
and find it easy to use.
by Mr xxxxx (26 Feb 2013)
The carafax sealant arrived quickly and was put to good use when i fitted a new vent in my van. The sealant consistency is excellent and the screws pulled down nicely to allow the sealant to do it's job. This is incredible value sealant which made a refreshing change.
Caravan Non-drying Sealant
by alan forrester (12 Feb 2013)
all though I have not yet used these tubes of sealer I have in the past and find them very good, one tip is to put the tube in a bowl of hot water as in cold weather there harder to squeeze in the gun.
by Mr blackall (03 Aug 2012)
It does what it says on the tube.
by Mr Fryar (26 Jun 2012)
recommended to me. Good product - does what it says.
Caravan Mastic Sealant
by foxy (16 Mar 2012)
arrived fast, found it to be horribly gooey, sticky, in fact PERFECTLY SUITED to sealing damaged panels on this old caravan ---- some left so used on open cille joints on an old Triumph Stag -- IDEAL. Now wondering wether this is ok as anti-nagging device for 'er indoors ?? maybe not, far too useful in my workshop. Forget Screwfix & B&Q, These are my prefferred suppliers in furure
by Tony (10 Mar 2011)
Excellent it "does what it says on the tin". The winter has taken its toll, and I hope this sealant will prevent a recurrence.
Caravan Non Dry Sealant
by Medic (01 Nov 2010)
Great product. Makes all rooflights, etc totally waterproof and keeps its form and doesnt dry out. Hightly recommended.
Caravan Non Dry Sealant
by A.H. Caravan Serving and repairs. (19 Jul 2010)
This stuff is really what is needed to ensure that no water ingress happens after fitting things like an external barbecue point. Coupled with the good service and fast delivery what more coul you need.
3 FAQs on the Soudal Butyrub Non-Setting (Permanently Plastic) caravan sealant (White)
I have a 7 year old Dethleffs advantage motorhome with Heki 3 plus skylight which has just started leaking slightly. Having looked at your technical drawings it looks as if the only sure way to solve the problem will be to remove it completely and reseal.
Am I right in this assumption and if so is this as straight forward as it would appear? I am a bit concerned that removing the old sealant may not be easy. Could you please advise:
1. what I am likely to need to remove the old sealant
2. what sealant should be used
3 there also appears to be a rubber seal beneath the other frame - will this need replacing at the same time?
4 can i get all the required parts from you?
Thanks in advance for your help
This is a straightforward job providing a non setting sealant was used during manufacture. Once the fixing screws have been removed then the frame should lift away from the roof of the vehicle. The ease with which it lifts will depend upon the sealant used. We recommend using a non setting sealant when replacing such as our ref. 205932. The old sealant will need to be removed with a chisel type tool. The rubber seal should not need replacing unless it is cracked.
I asked for advise on which sealant is recommended for Seitz S4 windows when fitting a new rubber outer frame to outer wall seal on my caravan. On 10th. August & 29th August 2013. I have not yet received the Seals ordered from yourselves. But I would appreciate an answer to my question, as I do not wish to use a wrong Sealant for this situation. Many Thanks.
by Adrian Meek
We would normally use a non setting mastic such as the Carafax IDL.
Hi I have just purchased a REMIS 400 skylight from you, can I use Sikaflex 512 as a seal between the skylight and the roof
by Tony Taylor
Yes you can but it is not easy to remove should you need to change the rooflight in the future, We normally use a non setting mastic such as Carafax IDL.
If you’ve changed your mind about keeping your purchase, please return it in its original condition with proof of purchase and we’ll exchange or refund it. Unless faulty, this should be within 30 days of receiving your order. By original condition, we’d expect this to mean that you’ve kept packaging and labels, and that the item is undamaged and unused.
For further information of how to return your item, please visit the "Returning an Unwanted/Faulty/Damaged Item" section on our Help Page.
Did you know we have been established and have been in the caravan and motorhome industry for over 50 years?
As you are an international customer, we can't calculate your shipping price automatically. You will notice that it has defaulted to QUOTE REQ.
Please click the 'Send Shipping Request' button below and we will then work out the shipping cost and email you a link that will allow you to pay securely for the complete order. This usually takes much less than one working day.
Low Rate CreditAvailable on 12, 18, 24 or 36 month terms. Spread the cost of your purchase with a low rate 14.9% fixed rate APR.
Leisureshopdirect Ltd acts as a credit intermediary and offer credit products provided exclusively by Klarna Bank AB (publ). Klarna Bank AB (publ) is Authorised by the Swedish Financial Services Authority (Finansinspektionen) and is subject to limited regulation by the Financial Conduct Authority. Details about the extent of our regulation by the Financial Conduct Authority are available from us on request. Finance is only available to permanent UK residents aged >18, subject to status, terms and conditions apply.
For further information, please visit our finance page: Finance Page Examples The below example takes just the value of this product. There may be further costs such as shipping which have not been taken into account. To see a final figure please continue to checkout.
We have taken the decision to keep our warehouse open to allow customers to buy items during this difficult time. We have taken many precautions to protect the Health & Safety of our staff and to follow the guidelines issued by the government:
All of our office staff are working remotely from home but can still be contacted by email or instant chat.
We are operating a split shift system with the warehouse staff so there is never more than 2 people in the warehouse at once. The two people working together are working in different areas of the warehouse so will be more than 2 metres apart at all times.
For the latest information and advice on COVID-19, please refer to the latest updates by the UK Government.
Frequently Asked Questions 1. Can I place an order? Will Leisureshopdirect deliver my parcel?
Yes, we are continuing to serve customers. You can check the current delivery times on the product pages as normal. When selecting a delivery address, please be aware that companies and businesses may be closed and unable to receive parcels. Therefore, please double check the delivery address before placing your order.
2. Are delivery times affected?
Our collections by our couriers are happening as usual. As it stands, delivery times are not being affected too much. Please be aware though that Royal Mail and other couriers are sometimes prioritising essential items so please bear with us if your delivery takes slightly longer than expected.
3. Is it possible to return items?
Yes, you can continue to return items as normal as long as you follow the government guidelines about leaving your house.
4. Is it safe to receive orders?
The likelihood of an infected person contaminating goods is low and the risk of catching the virus that causes COVID-19 from a package that has been moved, travelled, and exposed to different conditions and temperature is also low. You can find the latest information on COVID-19 on the information pages of the UK Government and the World Health Organization.
5. Is it possible to reduce contact with the driver when they deliver my order?
Yes. Drivers have been advised to reduce contact with customers by placing packages at the customer’s doorstep and stepping back. If an ID check is required, these are now performed at a distance.